split screen windscreen chrome
Forum rules
By using this site, you agree to our rules. Please see: Terms of Use
By using this site, you agree to our rules. Please see: Terms of Use
split screen windscreen chrome
\whats the best way to fit the splitscreen chrome on a fitted screen,many thanks stevie
-
- Series MM Registrar
- Posts: 10183
- Joined: Sun Jul 24, 2005 11:39 pm
- Location: Reading
- MMOC Member: No
Re: split screen windscreen chrome
Centre pillar and glass both in,just how to get the surround fitted,the best way.is it best to fit ths surround into the rubber with the windows out and then refit the whole lot?ta much
-
- Minor Legend
- Posts: 3010
- Joined: Sun Sep 09, 2007 10:42 pm
- Location: Whiteabbey, Co Antrim
- MMOC Member: Yes
Re: split screen windscreen chrome
The way I did it was to put a fine peice of string in the chrome channel and once the screen was fitted to carefully insert the chrome surround under the clips at the top and bottom, start to fit with a screwdriver and once started you should be able to pull the rest in with the string. A very fiddly and time consuming job but worth it when it finally goes in.
Too many Minors so little time.....
Re: split screen windscreen chrome
I don't know if this helps or not! Maybe it's the opposite problem.
Mine came loose on the drivers side and was only held in place by the central clips. I put some black adhesive on the rubber and refitted holding in place with tape until the adhesive set. Its now very solid and secure.
I have the windscreen installation procedure from an old manual, I will try and attach,but maybe too big.[frame][/frame]
Mine came loose on the drivers side and was only held in place by the central clips. I put some black adhesive on the rubber and refitted holding in place with tape until the adhesive set. Its now very solid and secure.
I have the windscreen installation procedure from an old manual, I will try and attach,but maybe too big.[frame][/frame]
1956 Morris Minor Series II
1959 MGA 1600 Roadster
1966 Jaguar Mk2 3.8 MOD
1959 MGA 1600 Roadster
1966 Jaguar Mk2 3.8 MOD
Re: split screen windscreen chrome
pm sent
1956 Morris Minor Series II
1959 MGA 1600 Roadster
1966 Jaguar Mk2 3.8 MOD
1959 MGA 1600 Roadster
1966 Jaguar Mk2 3.8 MOD
Re: split screen windscreen chrome
Hi,
Does anyone know where I could get a replacement chrome strip for the split screen rubber (the surround not the centre strip)
Mine is very shabby and has dents.
Cheers
Steve B
Does anyone know where I could get a replacement chrome strip for the split screen rubber (the surround not the centre strip)
Mine is very shabby and has dents.
Cheers
Steve B
-
- Minor Legend
- Posts: 2180
- Joined: Fri May 30, 2008 9:41 pm
- Location: Sutton Coldfield
- MMOC Member: No
Re: split screen windscreen chrome
Sorry, they are obsolete and are as common as rocking horse poo.... probably best to keep and re-use the one you have.Birchall wrote:Hi,
Does anyone know where I could get a replacement chrome strip for the split screen rubber (the surround not the centre strip)
Mine is very shabby and has dents.
Cheers
Steve B
My Minor:
A Clarendon Grey 1953 4 Door Series II.
MMOC - 66535
A Clarendon Grey 1953 4 Door Series II.
MMOC - 66535
Re: split screen windscreen chrome
I suspected / feared that this would be the situation.Dean wrote:
Sorry, they are obsolete and are as common as rocking horse poo.... probably best to keep and re-use the one you have.
I will try to get them in as good a condition as I can then!
Cheers
Steve B
-
- Series MM Registrar
- Posts: 10183
- Joined: Sun Jul 24, 2005 11:39 pm
- Location: Reading
- MMOC Member: No
Re: split screen windscreen chrome
At least you have the trim, which is more than a lot of cars have.
[sig]3580[/sig]
-
- Minor Legend
- Posts: 1024
- Joined: Fri Dec 18, 2009 5:06 pm
- Location: Nottingham
- MMOC Member: No
Re: split screen windscreen chrome
How is the trim different/identifiable from the later single piece windscreen style?
___Anne___
Re: split screen windscreen chrome
The split screen is smaller and has tighter radii in the lower corners. So the later trim is the wrong shape. The profile is similar and the later trims were stainless steel as oppose to the chrome plated brass of the split screens.
1956 Morris Minor Series II
1959 MGA 1600 Roadster
1966 Jaguar Mk2 3.8 MOD
1959 MGA 1600 Roadster
1966 Jaguar Mk2 3.8 MOD
-
- Newbie
- Posts: 4
- Joined: Fri Dec 03, 2010 9:52 am
- MMOC Member: No
Re: split screen windscreen chrome
Just wondering about the specifics of fitting the chrome surrounds. Someone mentioned adhesive - is this necessary or are the clips all that is needed?
Also, I note that there are small holes at the very ends of the surround, which will fall underneath the clips - are screws meant to be used here?
Also, I note that there are small holes at the very ends of the surround, which will fall underneath the clips - are screws meant to be used here?
-
- Series MM Registrar
- Posts: 10183
- Joined: Sun Jul 24, 2005 11:39 pm
- Location: Reading
- MMOC Member: No
Re: split screen windscreen chrome
It all depends on the condition of the windscreen rubber and the trim. If both are good then the trim should be held in the grooves in the rubber, if not then you will have to resort to strong adhesive and masking tape to hold the trim in place whilst the glue dries. The ends of the trim should sit under the ends of the V shaped clips.
When you have tried the water test you will find that the screen leaks like a sieve and you will have to start again.
When you have tried the water test you will find that the screen leaks like a sieve and you will have to start again.
[sig]3580[/sig]
Re: split screen windscreen chrome
I've always wondered about those holes no where for a screw to go that I could see,wonder if the factory had some way of using them for pulling the surround onto the rubberRebeccaLovesMorris wrote:
Also, I note that there are small holes at the very ends of the surround, which will fall underneath the clips - are screws meant to be used here?
-
- Newbie
- Posts: 4
- Joined: Fri Dec 03, 2010 9:52 am
- MMOC Member: No
Re: split screen windscreen chrome
Thnaks for the advice, guys,
The rubbers are brand new (Bull Motif) and the trims reclaimed (MMOC) and rechromed, so I'm good to go. The only snag seems to be that the garage which tried (and failed) to replace the rubber has 'mislaid' one of the clips...
The rubbers are brand new (Bull Motif) and the trims reclaimed (MMOC) and rechromed, so I'm good to go. The only snag seems to be that the garage which tried (and failed) to replace the rubber has 'mislaid' one of the clips...
-
- Series MM Registrar
- Posts: 10183
- Joined: Sun Jul 24, 2005 11:39 pm
- Location: Reading
- MMOC Member: No
Re: split screen windscreen chrome
Inform the garage that the clips are unobainable and tell them to find the clip or else. I can never understand how some garages can be so careless with parts,
[sig]3580[/sig]
Re: split screen windscreen chrome
Hi everyone
I have a 1950 MM series and wish to fit the 2 chrome strips into the front window rubber. However I am missing the 2 retainer clips that fit under the centre chrome strip I presume. Can these be obtained or something made to do the job????
I have never seen these clips so do not know what they look like. Are they necessary or is another method available?
Thankds Tony
I have a 1950 MM series and wish to fit the 2 chrome strips into the front window rubber. However I am missing the 2 retainer clips that fit under the centre chrome strip I presume. Can these be obtained or something made to do the job????
I have never seen these clips so do not know what they look like. Are they necessary or is another method available?
Thankds Tony
-
- Minor Legend
- Posts: 1460
- Joined: Sun Sep 25, 2011 6:32 pm
- Location: Clacton On Sea, Essex, ENGLAND.
- MMOC Member: Yes
Re: split screen windscreen chrome
These clips are very hard to come by.
The last set I found on Ebay recently sold for £56.00.
The last set I found on Ebay recently sold for £56.00.
-
- Minor Fan
- Posts: 399
- Joined: Wed Apr 15, 2009 11:51 pm
- Location: Usually on the naughty step
- MMOC Member: Yes
Re: split screen windscreen chrome
I am not sure if I am right but I believe the holes in the ends of the metal split windscreen trims are there so the delicate pieces could be hung up in the chroming process. They are hidden away in the final assembly.
Busy collecting parts for my '52 MM Convertible and 1949 Saloon restorations. :o